Product Name

:

COAL REMOVER RX HOLD

Product Type

:

Cargo Hold and Tank Cleaner

Company Details:

RX MARINE INTERNATIONAL
105, A wing , BSEL , TECH PARK.
VASHI ,NEW BOMBAY 400703 INDIA

Phone

:

+91 22 27815541

Fax

:

+91 22 2781 1318 :::AOH :0091 9821214367

Email

:

mail@rxmarine.com/

Chemica Name

CAS #

% BY WEIGHT

NaOCl

7681-52-9

40-50

Surfactant

NA

60-40

Swallowing  Swallowing

Eye  

Can cause permanent eye injury.  Symptoms include stinging, tearing, redness, and swelling of eyes.  Can injure the cornea and cause blindness.   

 Skin   

Can cause permanent skin damage.  Symptoms may include redness, burning, and swelling of skin, burns, and other skin damage. Additional symptoms of skin contact may include:  skin blistering,  hair loss, Passage of this material into the body through the skin  is possible, but it is unlikely that this would result in harmful  effects during safe handling and use.

this materrmful or fatal.  Symptoms may include severe stomach and intestinal irritation (nausea, vomiting, diarrhoea), abdominal pain, and vomiting of blood.  Swallowing this material may cause burns and destroy tissue in the  
mouth, throat, and digestive tract.  Low blood pressure and shock may occur as a result of severe tissue injury. 

  Inhalation    

It is possible to breathe this material under certain conditions of handling and use (for example, during heating, spraying, or   stirring).  Breathing this material may be harmful or fatal.  Symptoms may include severe irritation and burns to the nose, throat, and respiratory tract.

Target Organ Effects 

This material (or a component) has been shown to lower activity of certain immune system cells in experimental animals.  The significance of this effect with respect to human health is uncertain.  

Developmental Information 

There are no data available for assessing risk to the fetus from    
maternal exposure to this material. 

Primary Route(s) of Entry   

Inhalation, Skin contact, Eye contact.
 

Eyes   

If material gets into the eyes, immediately flush eyes gently with water for at least 15 minutes while holding eyelids apart.  If  symptoms develop as a result of vapor exposure, immediately move individual away from exposure and into fresh air before flushing   as recommended above.  Seek immediate medical attention. 

Skin  

Immediately flush skin with water for at least 15 minutes while removing contaminated clothing and shoes.  Seek immediate medical attention.  Wash clothing before reuse and discard contaminated shoes.  

Swallowing 

Seek immediate medical attention.  Do not induce vomiting.  Vomiting will cause further damage to the mouth and throat.  If an individual is conscious and alert, immediately rinse mouth with water and give milk or water to drink.  If possible, do not leave   individual unattended.

Inhalation

If symptoms develop, immediately move individual away from exposure and into fresh air.  Seek immediate medical attention; keep a person warm and quiet.  If person is not breathing, begin artificial respiration.  If breathing is difficult, administer oxygen. 

Note to Physicians  

Preexisting disorders of the following organs (or organ systems)  may be aggravated by exposure to this material:  skin, lung (for example, asthma-like conditions), immune system. 

Flash Point  

Not applicable 

Explosive Limit 

Not applicable

Autoignition Temperature  

No data   

Hazardous Products of Combustion

NA

Fire and Explosion Hazards  

 No special fire hazards are known to be associated with this product.   

Extinguishing Media 

Use an extinguishing media appropriate for surrounding fire.. 

Fire Fighting Instructions 

Water may be used to keep fire-exposed containers cool until fire is out.  Wear a self-contained breathing apparatus with a full facepiece operated in the positive pressure demand mode with appropriate turn-out gear and chemical resistant personal protective equipment.  Refer to the personal protective equipment  section of this MSDS.

Small Spill    

       Dilute with water and absorb onto a noncombustible absorbent        
       material.  

Large Spill 

       Prevent run-off to sewers, streams or other bodies of water. If     
       run-off occurs, notify proper authorities as required, that a       
       spill has occurred.  Collect and add slowly to large volume of      
       water.  Persons not wearing protective equipment should be          
       excluded from area of spill until clean-up is completed.  Stop      
       spill at source.  Dike to prevent spreading.  Pump to salvage       
       tank. 

Handling 

Containers of this material may be hazardous when emptied.  Since   
emptied containers retain product residues (vapor, liquid, and/or   
solid), all hazard precautions given in the data sheet must be      
observed.  Emergency eyewash fountains and safety showers should    
be available in the immediate vicinity of potential exposure
 

Eye Protection  

Chemical splash goggles and face shield (8" min.) in compliance with OSHA regulations are advised; however, OSHA regulations also   
permit other type safety glasses. (Consult your industrial hygienist.)  

Skin Protection   

Wear impervious gloves (consult your safety equipment supplier).    
To prevent skin contact, wear impervious clothing and boots.. 

Respiratory Protections  

If overexposure has been determined or documented, a NIOSH/MSHA     
jointly approved air supplied respirator is advised in absence of   
proper environmental control.  OSHA regulations also permit other   
NIOSH/MSHA respirators under specified conditions.  (See your       
safety equipment supplier.)  Engineering or administrative          
controls should be implemented to reduce exposure.

Engineering Controls   

Provide sufficient mechanical (general and/or local exhaust)        
ventilation to maintain exposure below level of overexposure (from  
known, suspected or apparent adverse effects).  

Exposure Guidelines   

Component    

Boiling Point  

(for component) 212.0 F (100.0 C) 

Vapor Pressure   

(for component) 17.500 mmHg  

Specific Vapor Density    

No data   

Specific Gravity    

1.220 – 1.250 @ 68.00 F

Liquid Density   

10.400 lbs/gal @ 68.00 F 1.250 kg/l @ 20.00 C   

Percent Volatiles  

87.5% 

Evaporation Rate  

SLOWER THAN ETHYL ETHER  

Appearance  

No data  

State  

LIQUID  

Physical Form  

HOMOGENEOUS SOLUTION 

Color  

CLEAR TO YELLOW LIQUID   

Odor   

CHLORINATED 

pH    

12.5-13.50  

Solubility in Water  

SOLUBLE    

Hazardous Polymerization  

Product will not undergo hazardous polymerization.  

No data 

No data

Waste Management Information  

Dispose of in accordance with all applicable local, state and federal regulations.    

DOT Information

 49 CFR 172.101  

 DOT Description:  

 Mixture HYPOCHLORITE SOLUTIONS,8,UN1791,III   

Container/Mode:  

 50 Ltr DRUM/TRUCK PACKAGE 

NOS Component:   

Not applicable    

RQ (Reportable Quantity)

  – 49 CFR 172.101  

Product Quantity (lbs)

 Component    

 
Chemical Weapons Convention:  No     TSCA 12(b):  No     CDTA:  No
SARA 311/312:  Acute: Yes      Chronic: No   Fire: No  Pressure: No
Reactivity: No          (Mixture / Liquid)

Australian Hazchem Code: None allocated.
Poison Schedule: S5
This MSDS has been prepared according to the hazard criteria of the Controlled Products Regulations (CPR) and the MSDS contains all of the information required by the CPR
                   

The information accumulated herein is believed to be accurate but   is not warranted to be whether originating with the company or not. Recipients are advised to confirm in advance of need that the information is current, applicable, and suitable to their  circumstances.